Lessons from a Tragedy
A32-year-old general manager of a Buffalo Wild Wings restaurant died November 7 in Burlington, Massachusetts,
after being exposed to fumes from an accidental mixture of two
My mind of course went to bleach and
ammonia. Not so here.
The chemicals involved were Scale Kleen
and Super 8, both provided by the same
chemical supplier. Despite the manager’s
attempts to squeegee the mixture off the floor,
I scanned the safety data sheets available on the chemical
supplier’s website to see what warnings I could find. They weren’t
Scale Kleen is a concentrated, highly acidic detergent used to
remove scale deposit. It is also a general-purpose cleanser for use
on a variety of surfaces. Its safety data sheet lists phosphoric acid
and nitric acid as ingredients, but no information was provided
about the pH. The sheet did state that it is acidic, but only in
the section under transport conditions. It did, however, note that
this detergent is incompatible with sodium hypochlorite, strong
alkalis, and soft metals.
Super 8, sodium hypochlorite, is used on food contact
surfaces as a sanitizer without a rinse. It is also used to sanitize
utensils, glassware, and equipment. Its safety data sheet states
that it is incompatible with strong acids, nitrogen, and oxidizers.
Lesson 1: Chemical suppliers, when selling incompatible
chemicals to the same customer, MUST COMMUNICATE
APPROPRIATE USE AND WARNINGS.
Lesson 2: Restaurant staff SHOULD NOT COMBINE
CLEANERS/SANITIZERS unless the supplier (or other
knowledgeable individual) has communicated that it is safe to do
Lesson 3: TRAINING, TRAINING, TRAINING (chemical
safety, what to do in case of exposure, etc.).
Cleaning and sanitizing is meant to kill microbes. When
worker safety is compromised, or worse, it’s a tragic reminder for
all of us that food safety also includes the well-being of those
who make it happen.
Barbara VanRenterghem, Ph.D.
CEO, The Target Group Inc. Don Meeker
Publisher Stacy Atchison
Head Elf Bobby Meeker
Editorial Director Barbara VanRenterghem, Ph.D.
Director of Sales Adam Haas
Art Director/Production Craig Van Wechel
Digital Editor Tiffany Maberry
Circulation Manager Andrea Karges
Administrative Manager Allison Demmert-Poland
Publishing Office 1945 W. Mountain St.
Glendale, CA 91201
Production Office 5392 Lighthouse Pt. Ct.
Loveland, CO 80537
Barbara VanRenterghem, Ph.D. • 508.210.3149
Tiffany Maberry • 678.853.1062
Bobby Meeker • 818.842.2829
Adam Haas • 321.804.4319
FOOD SAFETY MAGAZINE (ISSN 1084-5984) is published bimonthly by
The Target Group Inc., 1945 W. Mountain St., Glendale, CA 91201;
(818) 842-4777; Fax (818) 955-9504; E-mail firstname.lastname@example.org. Periodicals Postage Rate paid at Glendale, CA, and
additional mailing offices. Subscriptions: Free to qualified subscribers
as defined on the subscription card; $85.00 per year for nonqualified
subscribers. Back Issues: $10.00 per copy, prepaid. Change of Address:
Notices should be sent promptly; provide old mailing label as well as
new address. Allow two months for change. Editorial Contributions:
Unsolicited manuscripts should be submitted to: Barbara
VanRenterghem, Ph.D., Editorial Director at: email@example.com. Notice—Every precaution is taken to ensure accuracy
of content; however, the publishers cannot accept responsibility for
the correctness of the information supplied or advertised or for any
opinion expressed herein. Postmaster: Send address changes to Food
Safety Magazine, 1945 W. Mountain St., Glendale, CA 91201. ©2020
by The Target Group Inc. All rights reserved. Reproduction in whole or
part without written permission is strictly prohibited. The publishers
do not warrant, either expressly or by implication, the factual accuracy
of the articles or descriptions herein, nor do they so warrant any views
or opinions offered by the authors of said articles and descriptions.